CFC Offroad KTM RFS (Racing Four Stroke) Clutch Cover 250-400-450-520-525...
download 1. Wash engine sidecase to remove any dirt, grease, oil, etc. 2. Clean engine sidecase and the CFC case guard with quick drying solvent such as electrical contact cleaner or brake cleaner 3....
View Article2007 KTM 250 XC-F, XCF-W, EXC-F 400 XC-W, EXC RACING 450 XC, XC-W, EXC RACING...
download Headlamp switch (XC-W) In this model the headlamp is switched on with the pull switch [1] . Flasher switch The flasher switch is a separate unit and is mounted on the left portion of the...
View ArticleToyota Camry, Celica, Corolla, MR2 (1995), Paseo, Pickup (1995), RAV4 (1996),...
Download Disconnect negative battery cable. On 2.2L (5S-FE) models, remove battery and cruise control actuator. On all models, remove air cleaner case with air intake hose. Remove clutch release...
View ArticleHARLEY DAVIDSON BIG TWIN SPIGET MOUNT CARBURETOR INSTALLATION MANUAL
download A. BEFORE INSTALLATION OF YOUR NEW ZENITH CARBURETOR, NSPECT THE RUBBER MANIFOLD SEAL FOR NICKS,CRACKS, OR DEBRIS. APPLYING A LIGHT FILM OF PETROLEUM BASED LUBRICANT AROUND THE INSIDE LIP OF...
View Article2006 KTM 250 SX-F 250 EXC RACING 400 EXC RACING 450 SX, XC, EXC RACING 525...
download Hot start lever (250 SX-F) If you pull the red hot start lever [1] during the starting procedure backward, a bore in the carburetor will be opened through which the engine may take in...
View ArticleKTM 250/300/380 SX,MXC,EXC ENGINE REPAIR MANUAL
download Carburetor adjustment Basic information on the original carburetor setting The original carburetor setting was adapted for an altitude of approx. 500 meters (1600 ft.) above sea level, and the...
View ArticleHSR Carburetor Total Kits Installation Instructions
download Intake Manifold: 1. Install MAP sensor in Mikuni manifold (Twin Cam only). 2. Attach the Mikuni manifold to the engine. Align the manifold before tightening the bolts. The flange surface of...
View Article2008 KTM 50 SX JUNIOR 50 SX OWNER'S MANUAL
download Choke Dell’Orto carburetor PHVA 14 DS (50SXJunior) Choke lever [1] is mounted to the right side of the carburetor. If you move the choke lever up to the stop, a hole is opened in the...
View ArticleKTM 250/ 300/ 380 SX,MXC,EXC ENGINE REPAIR MANUAL
download Repair manual KTM 250 / 300 / 380 Art No 3206004 -E 2-2C main jet jet needle jet needle air control screw idle adjusting screw idle jet throttle valve Idling range A Operation with closed...
View ArticleKTM 60 SX / 65 SX REPAIR MANUAL ENGINE
download Carburetor adjustment Basic information about the original carburetor setting The original carburetor setting was adapted for an altitude of approx. 500 meters (1600 ft.) above sea level, and...
View Article